Utilizing a Pellet Tube for Smoking Meat
For those who use an electrical smoker and wish to have fixed smoke for five+ hours otherwise you use a pellet smoker and simply aren’t getting sufficient smoke taste, I’ve the answer for you!
A pellet tube full of pellets and lit at one finish will present fixed smoke for five+ hours relying on it’s measurement and the way full you fill it with pellets.
A few of you might be right here since you’ve already tried to make use of a pellet tube and may’t preserve the darn factor lit! Properly, I’ll present you methods to repair that downside as effectively.
- Pellet tube
- Pellets
- Torch/Lighting gadget
First, you’ll need a pellet tube. I take advantage of one which I discovered on Amazon actually low-cost and it really works nice!
Additionally, you will want pellets and virtually any pellets will work. I typically use the Pit Boss model from Wally world as a result of they’re low-cost they usually work effectively within the smoke tube in addition to in my pellet people who smoke.
You may as well buy pellets on amazon however they may value greater than what you’ll find regionally. Your alternative there!
Third and presumably most necessary, you’ll need a propane or butane torch. I just like the bigger Bernzomatic torches like plumbers use however the smaller creme brûlée torches will even work simply advantageous.
Right here’s the torch I take advantage of which you’ll find at Wally World, HD or virtually some other retailer that sells {hardware} and instruments.
Fill the tube all the way in which full with dry pellets.
Observe: I’ve been identified to microwave my pellets in a bowl for a minute or two earlier than putting them within the tube to ensure they’re dry however that is simply one thing I do to ensure, it’s most likely not typically obligatory.
I have a tendency to put the smoke tube horizontally on a flat, fire-proof floor however I’ve seen some stand them straight up through the lighting process.
Which smoke tube place do you suppose is best? Publish it within the remark part beneath.
Activate the torch and maintain the flame to the pellets for about 45 seconds to get them to burning actual good.
As soon as they’re burning, enable them to burn for round 7 minutes to create a very nice mattress of coals. This mattress of coals is likely one of the key elements that retains the pellets going for 4 to five hours unattended.
If the pellets are nonetheless burning after 7 minutes, blow out the flame and proceed on to the subsequent step.
Each smoker is completely different and placement is one thing that varies from smoker to smoker. The 2nd key element to creating positive the smoke tube retains smoking for hours on finish is air.
The smoke tube should get a provide of air by way of a vent, gap, opening, and so forth. in order that it might proceed burning.
As an illustration, I usually use a smoke tube within the Reqtec pellet smoker. I place it straight on the grate all the way in which to the left, proper subsequent to the probe entry gap and that offers it loads of air.
Within the Masterbuilt electrical people who smoke, the smoke tube will set on the underside rack proper subsequent to the woodchip chute. The chute must be open to permit air to enter and preserve the smoke tube going.
For those who don’t have a vent or opening, you may modify your smoker or grill to create an air inlet so long as this received’t void your current guarantee.
For those who use a smoke tube in your smoker, let me know within the remark space beneath what place works for you in your smoker. Make sure to tell us what sort, mannequin, technology, and so forth. of smoker you’ve.
Observe: I like to recommend NOT utilizing the water pan when utilizing a smoke tube. The additional moisture within the smoker may mess with the smoke tube staying lit and this isn’t good. If doable, go away the water pan dry when utilizing a smoke tube.
- Ensure the pellets are dry. For those who suspect the pellets are in the slightest degree damp, pour them right into a bowl and microwave them for a minute or two to assist dry them.
- Maintain the lighter/torch to the pellets for 45 seconds. This permits extra pellets to begin burning which will provide you with a greater mattress of coals to maintain the pellets burning contained in the smoker.
- Let the pellets burn uninterrupted for at the least 7 minutes to create that mattress of coals we talked about in #2 above.
- Ensure the pellet tube is getting ample air. The pellets should get a gentle provide of oxygen to proceed burning for hours on finish. If the pellets are going out, they might be starved for air.
For much more smoke taste, you should use wooden chips in with the pellets.
I like to recommend NOT utilizing wooden chips solely however layering them. As an illustration, a layer of pellets, then a layer of wooden chips, adopted by one other layer of pellets and so forth and so forth.
Pellets are likely to burn extra cleanly than wooden chips and whereas it is a wonderful thing about pellets, it additionally means the flavour could be much less robust than wooden chips.
I like to recommend putting pellets as your final layer and that’s the layer that you just mild to create mattress of coals.
Give it a attempt to see what you suppose.
In case you have different suggestions for lighting the pellet tube and/or retaining it lit for hours on finish, tell us within the comments area beneath.
Order Jeff’s Rubs and Barbecue Sauce TODAY!
✅ My rubs and sauce would be the smartest thing you’ve ever tasted and it’s a nice method to assist what we do!
Observe: You may as well order the formulation for my rubs and sauce and make these your self at residence. Seize these HERE and obtain instantly.
